Logo
FULL SITE MENU

Search results

  1. P

    Evinrude Dirty 30

    1984 E30ECRR SER. F036841 Just rebuilt a leaky carb that messed up the floor of the engine compartment. What's the best way to clean up that area. Thanks for your help. PW
  2. P

    84 Evinrude Fountain Display

    Just rebuilt the water pump and hooked up the earmuffs. When I turn on the water, it's pouring out of the weep holes in the gear case. Don't recall it doing this before. Wha'd I do wrong? Many thanks for your help, PW
  3. P

    84 Evinrude 30 impeller won't come off

    1984 Evinrude 30 E30ECRR Ser: F036841 About every 5 years, I rebuild the water pump, and forget about half of what I did the last time. I get the impeller to the top of the driveshaft and it jams on the splines. I took out the shim in the impeller even before I got to this step. I haven't tried...
  4. P

    Evinrude 30 fuel line replacement

    1984 Evinrude E30ECRR 30hp, Ser. #I've had the boat since 2009 and replaced the fuel lines with USCG certified line around 2015. I switched to what we in Michigan call "Rec Gas" (no ethanol). Any solid info about how often to change them again? Thanks for answering my question.
  5. P

    Mercruiser Injectors Not Injecting

    1995 Mercruiser 5.7L Magnum EFI (TBI) Tournament Ski Ser. # 0F562552 This boat ran great all last season and was put to bed in October with zero problems. De-winterized it today and no start. Fuel pump is pumping but injectors are not spraying. This is the TBI system, not the MPI, with two...
  6. P

    Mooring Cover?

    Hello all. I live in Metro Detroit, and my boats are exposed to full sun, wind and rain during our boating season (May - October). I need an over-bimini or over-tower cover for my 1995 Ski Sanger DLX20. Over 30 years of boating in my area, only this type of cover has a steep enough drop-off to...
  7. P

    Mercruiser Seawater Pump Rebuild

    1995 350 Magnum EFI Tournament Ski SerNo: 0F652552 Seawater Pump: 46-72774A50 Seawater Pump Kit Sierra 18-3237 ??? Hope this query finds you and yours well and happy. The pump ir original and its plastic impeller housing got replaced with a brass housing when I bought the boat in 2016. This...
  8. P

    1995 Mercruiser 350 Magnum Tournament Ski Stumbling

    Throttle Body EFI, Ser. OF562552 This engine powers a 1995 Ski Sanger DLX20 that I bought end of 2016. After a lot of work chasing down a fuel delivery problem, the boat has been running great for the last few years. Today it was stumbling off idle when trying to pull up a slalom skier. Usually...
  9. P

    Packing Gland Access Port

    1995 Ski Sanger 20DLX with 95 Mercruiser 5.7L Tournament Magnum Ski V8: Anybody know/remember how to open this cover? It's deck-mounted behind the engine cover in this direct-drive boat. I opened it six years ago to tighten the packing gland, but can't remember how it works. Tired prying it with...
  10. P

    Weatherproof Fabric Adhesive?

    I want to patch an acrylic boat cover with some leftover fabric the canvas shop gave me when they built it. The boat is at my dock from now until Oct. 1, exposed to sun, wind and rain the entire time. Looking for an adhesive that will stand up to those conditions. Pls don't refer me back to the...
  11. P

    1984 Evinrude 30hp E30ECRR Battery Spec

    I've been using a 550 CCA battery to start this outboard for years, which is overkill. When it's time to replace, I'd like to get the correct size and (I hope) save a little money. Or, could I swap in my old 550 CCA battery from my 5.7L V8 ski boat when it gives out, and use it for the outboard...
  12. P

    Shore Station guide-on replacement

    The attached photo is the shaft of a spring loaded technical term for guide-on at the four corners of my Shore Station SS36108 boat hoist. They center the boat on the bunks when you crank it up. The hoist is probably 20+-years old (bought it used) and the steel guide-ons are starting to break...
  13. P

    Freeze Warning Tonight

    MERCRUISER 350 MAG. EFI SKI (TBI) GM 350 V-8 1995Local weather issued a freeze warning. It's 47F now (4:30pm) and is predicted to drop to 32F by 6am tmrw before climbing back up. I just came back to town after a month away, and my 95 Sanger DLX20 has been on the hoist the whole time. Should I...
  14. P

    Bilge Pump Polarity?

    Just replaced the bilge pump in my 1995 Ski Sanger Tournament Tow Boat. As far as I know, it's a simple 12v negative ground electrical system. The pump was operational last season, but didn't run when I turned it on yesterday. Ordered the parts and Amazon delivered them today. I replaced to old...
  15. P

    Mercruiser 5.7 engine alarm?

    1995 Mercruiser 350 Magnum Tournament Ski TBI Ser. OF562552 This engine powers my 1995 Ski Sanger DLX20. I live in MI, and my buddy in CA has the same boat, just the 1994 model. Same engine, but his is carbureted. When I turn on the ignition, there is a very high-pitched beep that lasts about 3...
  16. P

    Thru-Prop Exhaust On Evinrude? Yes or No?

    1984 Evinrude 30 Mod. #E30ECRR, Ser. #F0368410 This powers my 1984 Harris Flotebote 240 Sunliner. When I bought the boat 11 years ago, it had a dinky prop with blades worn half off, and a cap on the prop hub. First thing I did was re-prop the boat per recommendation of a local prop house. The...
  17. P

    1984 Evenrude 30: Turn it down?

    Mod. #E30ECRR, Ser. #F0368410 Great little motor that's only giving trouble once in the last 11 years. But as I've gotten older, it seems to have gotten LOUDER (I know it's just my hearing is more sensitive.). It's on my '84 Harris Flotebote Sunliner 240 pontoon, hanging on the engine box off...
  18. P

    Brace Attachment

    1995 350 Magnum EFI Tournament Ski, ser. #0F562552 Installing new alternator when I found this little gem left by a previous owner. #1: Alternator belt tension brace jammed behind sea water pump brace bolted to block. #2: Unbolting reveals 2 bolt holes, one of which is rusted. #3: Bolting...
  19. P

    Velvet Drive fluid change

    Model 71C direct-drive 1:1. Fluid–Capacity: Dexron lll/Mercon–2 qt. Engine: 1995 Mercruiser 350 Magnum Tournament Ski EFI (TBI) Checked out a few youtube vids, which showed draining the trans via the fill port with a suction pump, but not draining the oil cooler and its hoses. The only vid that...
  20. P

    Alternator, Regulator or Gauge?

    1995 Mercruiser 350 Magnum Tournament Ski, 460 hours. At wakeboard/ski speeds (18/30 mph) the battery gauge is pinned to the top reading, 16V. Is this normal? I have a multi tester if checking is required. Just need a how-to on the procedure. Many thanks for your help, PW
Back
Top