Logo
FULL SITE MENU

Search results

  1. T

    Oil water mix everywhere.

    The starboard side riser has rust where it joins the manifold. System has a lot of rust in it. Used a endoscope on the cylinders. The only one that shows water intrusion is #6. Going to compression all next. Boat was winterized and used a bilge heater.
  2. T

    Oil water mix everywhere.

    91 StarCraft Eurosport 5.0LX Alpha one Gen two. When I first got it, ran with the muffs and found a out leak from the out drive. Repaired that and found water mix in the outdrive oil. Pressure tested and found the leaks. Fixed that. Checked all fluids and everything fine. Took it to the lake and...
  3. T

    Vacuum test on alpha 1 gen 2

    Got the low end back together with new parts and is holding pressure. Thanks everyone. Put it back together in the morning..
  4. T

    Vacuum test on alpha 1 gen 2

    Thanks!
  5. T

    Vacuum test on alpha 1 gen 2

    Bought a new housing from powerboat supply.
  6. T

    Vacuum test on alpha 1 gen 2

    I’m sure that’s it! Thanks.
  7. T

    Vacuum test on alpha 1 gen 2

    No. So I guess replace the seal assy again and while it’s off, replace the lower water pump seal then retest.
  8. T

    Vacuum test on alpha 1 gen 2

    Installed a new lower shift shaft housing when I replaced the impeller. Pressure tested and is leaking from the lower shift shaft. Is it a bad part or is something else causing it?
  9. T

    Vacuum test on alpha 1 gen 2

    Thanks doing this morning..
  10. T

    Vacuum test on alpha 1 gen 2

    I had a oil leak from the right side water inlets and weap hole. I replaced the impeller and shift shaft seal. When I drained it, did have some water intrusion. Put it back together and ran it. Still water intrusion. Now I wish I would have replaced the seal carrier. I did inspect the prop seal...
  11. T

    Vacuum test on alpha 1 gen 2

    I know this is old, but where on the drive do you focus when doing a vacuum test?
  12. T

    Alpha one Gen two water intrusion.

    Thanks!
  13. T

    Alpha one Gen two water intrusion.

    Thanks. Will I be able to see/hear leaks with the unit on the boat?
  14. T

    Alpha one Gen two water intrusion.

    91, 5.0LX hasn’t been in the water lately. Ran it with the muffs and later developed an oil leak out of the weep hole on the outdrive. The shift shaft seal was leaking. Oil was milky. Replaced that and the impeller while I was in there. Made sure the o-ring was installed. Filled it up and ran it...
Back
Top